Autoblog

The National Highway Traffic Safety Administration says passenger airbags in some 2009 Chevrolet Impalas may have a potentially deadly flaw. Not only could the devices fail to inflate in a crash, but the inflator tube could rupture and hurl pieces of it at passengers. Sounds pretty bad, but there is good news for most Impala owners. According to NHTSA, the recall will only affect 79 Impalas, and not all of them will need replacement. Airbags found to be faulty will be completely replaced under the recall campaign at GM service centers.

Notices will be mailed out sometime this month to Impala owners who need to have their vehicles inspected. You can read the entire NHTSA description here.

[Source: Inside Line]

General Motors has nixed an optional hot-spray windshield washer system called HotShot from all of its cars and trucks after an electrical short in the systems caused the recall of 944,000 vehicles. GM told the National Highway Traffic Safety Administration that a short on the circuit board of the fluid heater could overheat the control-circuit ground wire. The problem has resulted in 34 warranty claims so far and three reports of fires may have been caused by the system. To fix the problem, dealers will add a wiring harness with an inline fuse, and all GM retail outlets should have the required parts to fix the problem free of charge by November 1. Vehicles affected include the Buick Lucerne and Enclave, the Cadillac DTS and Escalade, the GMC Yukon, Sierra and Acadia, the Saturn Outlook, the Hummer H2, and the Chevy Silverado, Avalanche, Tahoe, and Suburban.

GM blames the system's suburban Detroit supplier, Microheat, for the problem, and the small company has reportedly shrunk in size in preparation of forever closing its doors. The General wants Microheat to pay for the recall, which is estimated to cost between $20 and $25 million, and the small supplier has countered by reminding the automaker that it's still owed $3.7 million for parts and tooling. The whole affair is a shame, as heated windshield washer fluid is a nice luxury that makes de-icing and de-bugging your windshield a hands-off affair. As far as we know, Microheat is the only supplier offering this technology, so when it goes, so does the option altogether.

[Source: Automotive News, sub. req'd]

2008-'09 Kia Rondos packing four-cylinder engines are being recalled to fix a fuel pump issue that could lead to fuel starvation. Nearly 7,000 Rondos in EX and LX trim are effected, and will get an improved fuel pump to resolve the issue. The NHTSA has warned that the problem is unusually severe, and vehicle behaviors such as poor starting and hesitation could lead to a crash. If you own Kia's funk-tacular MPV with the 2.4-liter engine, get thee to a dealer, or call Kia at 800-333-4542.

[Source: Inside Line]

Owners of 2006-08 Chevrolet HHRs should bust out their screw drivers because General Motors will be issuing a recall for deficient instrument panel storage bin latches. The weak latch does not meet federal safety compliance test standards, as it allows the dash bin door to swing open under specific crash conditions. The NHTSA was none too pleased with the possibility of passenger injury from insecure objects. Storage bin latch reinforcement kits will be sent to HHR owners at the General's expense. Recipients will have the option of performing the modification on their own or taking it into a dealership for the necessary repair. Notices will begin flowing once sufficient parts are available, which should be by November.

[Source: Automotive News, sub req'd]

In the ongoing quest to make our cars more user-friendly, automakers have been adding more and more techno-goodies to make our lives just a bit easier, as well. Unfortunately, these features occasionally do the exact opposite as electrical gremlins take control and make them malfunction. Such is the case with a 857,735 vehicles from General Motors built between 2006 and 2008 that are equipped with heated windshield washer fluid. Apparently, the system is liable to short out, causing it to stop working and even smoke, give off an odor, and make other on-board electronic systems go haywire. To remedy the problem, dealers will add a new wiring harness with an in-line fuse, which will short out before the problematic printed electrical circuit does the same. We've pasted a list of all the affected vehicles after the break.

[Source: NHTSA via Good Car Bad Car]

Click above for high-res gallery of the 2009 Jaguar XF

If you have a 2009 Jaguar XF, you should hop down to your dealer to have the rear safety belt assembly looked at. Jaguar is recalling 7,900 of the '09 cars because in an accident the rear occupants might not be properly restrained. To find out more you can call Jaguar at 1-800-452-4827, or make an appointment at your local Jaguar dealer.


[Source: Carscoop]

Some 2008-model Hyundai Elantras are being recalled due to fuel pumps that could lose pressure and decreasing engine performance. In Elantras with the 2.0-liter Beta engine, gasoline with ethanol added creates a buildup of film on the pump's electrical contacts. This can cause the engine to hesitate during starting or while running. The recall is voluntary, and if you have one of the affected cars, don't hesitate to contact your dealer.

[Source: Freep]

Click above for high-res gallery of the smart fortwo

Of all the possible reasons that a vehicle could be recalled, a poor paint job doesn't at first seem all that newsworthy. After all, cars could theoretically be recalled for exploding gas tanks, runaway engines or any number of horror-inducing problems. Bad paint? No harm, no foul -- just take it back and have it repainted properly. Unless, of course, that paint problem could lead to the loss of your windshield or roof while driving. This is exactly the worry that the NHTSA has with 43 smart ForTwo's, all sold in 2008. It seems that some adhesive was laid over the problematic paint, and if the paint lets go... so does the glue. While it's never happened to us personally, we tend to agree with the NHTSA's assessment that the sudden loss of either the glass in front of you or the ceiling protecting your dome could potentially lead to a crash. Anybody who's concerned can contact their dealer, assuming that they haven't already been notified of the problem.


[Source: Next Autos]

All owners of 2008 Honda Elements are being asked to stop driving their cars until they have had them inspected at their local Honda dealer. According to a recall issued by the National Highway Traffic Safety Administration, the front bushing bracket of the left trailing arm of the rear suspension may have been improperly welded. If it fails, it could separate from the trailing arm causing the suspension to release part of the wheel hub, thus leading to a loss of control or crash. Although only 241 Elements are potentially affected (there are specific VIN number ranges during certain production dates), Honda is notifying all owners immediately and will inspect and replace defective parts at no charge. Rather than taking a risk, err on the side of safety and call your Honda dealer if you've got the keys to a 2008 Element in your pocket.

UPDATE: According to Honda spokesman Chris Martin all the affected owners were already notified before this story was published. Approximately half of the affected vehicles were unsold and sitting on dealer lots. Those have already been repaired. If you haven't already heard from Honda than you should be fine.

[Source: NHTSA via Carscoop]

BMW is recalling 200,000 units of its 3 Series, 5 Series and X3 SUVs to repair potentially faulty air bag sensors. The National Highway Traffic Safety Administration website says the recall campaign covers 2004-2006 5 Series, 2004-2006 X3 and 2006 3 Series vehicles, though only those equipped with sport seats.

Apparently the problem is with the front passenger sport seat that, over time, develops cracks in its covering. An air bag sensor beneath the area can then be damaged so that the car no longer senses the weight of a passenger. That means, of course, the passenger airbag might not be deployed in an accident.

BMW is doing the right thing by quickly addressing the issue even though no accidents or incidents have been reported in relation to the problem. Also, according to NHTSA, the company will extend the warranties of several of BMW models to cover the issue for 10 years with no mileage restriction. A summary of the recall No. 08V384000 is available here from NHTSA.

[Source: Associated Press via CNN]